Product ID:MT STARTER 401, EP 4050
MSDS Date:09/13/1994
FSC:6850
NIIN:00N083118
MSDS Number: CGPQR

MINOLTA CORP

101 WILLIAMS DRIVE
RAMSEY, NJ 07446
US

Emergency Phone: 201-825-4000

Info Phone: 201-825-4000

Cage: GO339

MINOLTA CORPORATION

RAMSEY, NJ 07446 US

Telephone: 201-825-4000

Cage: 23736

CARRIER (CONSISTING OF INGS 2 - 5)

RTECS: 9999999ZZ

Fraction By Weight: >90%

OSHA PEL N/K

ACGIH TLV: N/K

FERRITE (FERROSPINEL)

CAS: 1317-54-0

RTECS: LK0495000

OSHA PEL N/K

ACGIH TLV: N/K

POLYESTER RESIN

OSHA PEL N/K

ACGIH TLV: N/K

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

SILICA GEL; (AMORPHOUS SILICA)

CAS: 112945-52-5

RTECS: VV7310000

OSHA PEL 6 MG/M3

ACGIH TLV: 10 MG/M3

TONER (CONSISTING OF INGS 7 - 10)

RTECS: 9999999ZZ

Fraction By Weight: <10%

OSHA PEL N/K

ACGIH TLV: N/K

STYRENE ACRYLATE COPOLYMER

CAS: 25153-46-2

OSHA PEL N/K

ACGIH TLV: N/K

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

ORGANIC PIGMENT

CAS: 32517-36-5

OSHA PEL N/K

ACGIH TLV: N/K

SILICA GEL; (AMORPHOUS SILICA)

CAS: 112945-52-5

RTECS: VV7310000

OSHA PEL 6 MG/M3

ACGIH TLV: 10 MG/M3

LD50 LC50 Mixture:LD50:(ORAL,RAT) >5 G/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:MINIMAL RESPIRATORY TRACT
IRRITATION MAY OCCUR AS WITH EXPOSURE TO LARGE AMOUNTS OF ANY
NONTOXIC DUST. MAY CAUSE COUGH AND RAISE PHLEGM. STARTER, AS A
MIXTURE, IS CONSIDERED A NUISANCE DUST. EYE IRRIT:MILD
CONJUNCTIVAL IRRIT (RABBITS). CHRONIC:TOX INFO:TONER PRESENTS A LOW
HAZARD FOR USUAL OCCUP (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CARBON BLACK:IARC MONOGRAPHS, VOL 65, PG
24-27, 1995:GROUP 2B.
Effects of Overexposure:HLTH HAZ:SETTINGS. BASED ON AVAIL DATA, HUMAN
EXPOS TO TONER HAS BEEN SHOWN TO CAUSE MINIMAL RESP TRACT IRRIT AS
MAY OCCUR W/LG AMTS OF ANY NON-TOX DUSTS. RSLTS OF ONE ANIMAL STUDY
WHERE RATS INHALED TONER THAT WAS TEN TIMES MORE RESPIRABLE THAN
COMMERCIALLY AVAIL TONER WERE OBSERVED TO HAVE NO LUNG CHANGES AT
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:WASH NOSTRILS, RINSE MOUTH. INGEST:DILUTE STOMACH
CONTENTS W/SEVERAL GLASSES OF WATER. EYES:FLUSH W/WATER FOR AT
LEAST 15 MINUTES. SKIN:WASH W/SOAP & WATER.

Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:IF DISPERSED IN AIR, STARTER, LIKE MOST
FINELY DIVIDED ORGANIC POWDERS, MAY FORM AN EXPLOSIVE MIXTURE.

Spill Release Procedures:IF SPILLED, SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE REQUIRED WHEN USED AS INTENDED IN
MINOLTA EQUIPMENT.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE.
Supplemental Safety and Health
EFTS OF OVEREXP:LOW EXPOSURES (THE MOST RELEVANT LEVEL TO POTENTIAL
HUMAN EXPOSURES). AT HIGHER LEVELS A SLIGHT DEGREE OF LUNG FIBROSIS
WAS OBSERVED DUE TO EXCESSIVE AMOUNTS OF DUST RETAINED IN LUNGS
FOR A PROLONGED INTERVAL.

Spec Gravity:3.2 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER; FAINT ODOR.

Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC.
AVOID BREATHING OF SMOKE.

Waste Disposal Methods:WASTE MAY BE DISPOSED OR INCINERATED UNDER
CONDITIONS WHICH MEET ALL FEDERAL, STATE & LOCAL ENVIRONMENTAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.